Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN 		License/Permit #
 BB026
Street Address
1560 STATE RT. 50 NORTH
City/State
 BOURBONNAIS, IL 		ZIP Code
 60914
No. of Risk Factor/Intervention Violations 3
No. of Repeat Risk Factor/Intervention Violations 2
Date 05/04/2023
Time In 01:55 PM
Time Out 03:15 PM
Permit Holder
JOE'S CATERING, INC. 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected X X
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition X  
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43 X In-use utensils: properly stored    
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47 X Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55 X Physical facilities installed, maintained & clean   X
56 X Adequate ventilation & lighting; designated areas used X  

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN Establishment #: BB026
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: QUAT 200 Heat: CHLORINE 100 °F
CFPM Verification (name, ID#, expiration date):
MICHELLE WEST
21156897
02/08/2026 		LORI DILLON
21739445
04/07/2025

01/01/1900

 

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
shredded cheese 41.00°F olives 40.00°F hot peppers 40.00°F
fries 0.00°F bread sticks 0.00°F watermelon 38.00°F
chicken 39.00°F mushrooms 42.00°F fish 0.00°F
lemons 41.00°F salad dressing 41.00°F sauce 200.00°F

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
15 Observed stuffed raw chicken stored over a container of raw fish. All raw foods shall be stored according to their cooking temperature. Chicken was relocated to the bottom shelf. COS,Repeat
16 C 4-602.11 (E): (E) Except when dry cleaning methods are used as specified under § 4-603.11, surfaces of UTENSILS and EQUIPMENT contacting FOOD that is not TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be cleaned: (1) At any time when contamination may have occurred; (2) At least every 24 hours for iced tea dispensers and CONSUMER self-service UTENSILS such as tongs, scoops, or ladles;  (3) Before restocking CONSUMER self-service EQUIPMENT and UTENSILS such as condiment dispensers and display containers; and (4) In EQUIPMENT such as ice bins and BEVERAGE dispensing nozzles and enclosed components of EQUIPMENT such as ice makers, cooking oil storage tanks and distribution lines, BEVERAGE and syrup dispensing lines or tubes, coffee bean grinders, and water vending EQUIPMENT: (a) At a frequency specified by the manufacturer, or (b) Absent manufacturer specifications, at a frequency necessary to preclude accumulation of soil or mold.
Observed the inner edge of the ice machine to be in need of cleaning. Clean and maintain by next routine inspection.
23 PF 3-501.17 (A-B) (E-G): (A)Except when PACKAGING FOOD using a REDUCED OXYGEN PACKAGING method as specified under § 3-502.12, and except as specified in ¶¶ (E) and (F) of this section, refrigerated, READY-TO -EAT, TIME/TEMPERATURE CONTROL FOR SAFETY FOOD prepared and held in a FOOD ESTABLISHMENT for more than 24 hours shall be clearly marked to indicate the date or day by which the FOOD shall be consumed on the PREMISES, sold, or discarded when held at a temperature of 5ºC (41ºF) or less for a maximum of 7 days. The day of preparation shall be counted as Day 1. (B) Except as specified in ¶¶ (E) - (G) of this section, refrigerated, READY-TO-EAT TIME/TEMPERATURE CONTROL FOR SAFETY FOOD prepared and PACKAGED by a FOOD PROCESSING PLANT shall be clearly marked, at the time the original container is opened in a FOOD ESTABLISHMENT and if the FOOD is held for more than 24 hours, to indicate the date or day by which the FOOD shall be consumed on the PREMISES, sold, or discarded, based on the temperature and time combinations specified in ¶ (A) of this section and: (1) The day the original container is opened in the FOOD ESTABLISHMENT shall be counted as Day 1; and (2) The day or date marked by the FOOD ESTABLISHMENT may not exceed a manufacturer’s use-by date if the manufacturer determined the use-by date based on FOOD safety. (E) Paragraphs (A) and (B) of this section do not apply to individual meal portions served or rePACKAGED for sale from a bulk container upon a consumer’s request. (F) Paragraphs (A) and (B) of this section do not apply to SHELLSTOCK.  (G) Paragraph (B) of this section does not apply to the following FOODS prepared and PACKAGED by a FOOD PROCESSING PLANT inspected by a REGULATORY AUTHORITY: (1) Deli salads, such as ham salad, seafood salad, chicken salad, egg salad, pasta salad, potato salad, and macaroni salad, manufactured in accordance with 21 CFR 110 Current good manufacturing practice in manufacturing, packing, or holding human food; (2) Hard cheeses containing not more than 39% moisture as defined in 21 CFR 133 Cheeses and related cheese products, such as cheddar, gruyere, parmesan and reggiano, and romano; (3) Semi-soft cheeses containing more than 39% moisture, but not more than 50% moisture, as defined in 21 CFR 133 cheeses and related cheese products, such as blue, edam, gorgonzola, gouda, and monterey jack; (4) Cultured dairy products as defined in 21 CFR 131 Milk and cream, such as yogurt, sour cream, and buttermilk; (5) Preserved FISH products, such as pickled herring and dried or salted cod, and other acidified FISH products defined in 21 CFR 114 Acidified foods; (6) Shelf stable, dry fermented sausages, such as pepperoni and Genoa; and (7) Shelf stable salt-cured products such as prosciutto and Parma (ham).
Observed a few items in the walk-in cooler to not have proper dates on them. Several items looked fresh and just had not received a label at the time of inspection. Provide for all food items to be labeled. Items labeled. COS
43 C 3-304.12 (A): During pauses in FOOD preparation or dispensing, FOOD preparation and dispensing UTENSILS shall be stored: (A) Except as specified under (B) of this section, in the FOOD with their handles above the top of the FOOD and the container.
Observed little dixie cups to be in several seasoning containers. Provide for only a cup with a handle to be used as a proper scoop. Remove and maintain by next routine inspection.
47 C 4-501.11 (B): (B) EQUIPMENT components such as doors, seals, hinges, fasteners, and kick plates shall be kept intact, tight, and adjusted in accordance with manufacturer's specifications.
Observed the seal gasket to the bar keg beer cooler to have a torn seal gasket at the bottom. Repair/replace and maintain by next routine inspection.
49 C 4-601.11(C): (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris.
Observed the tops of the bar roll coolers to be slightly sticky. Clean and maintain by next routine inspection.
55 C 6-501.12: (A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
Observed some of the ceiling tiles to be in need of cleaning or replacement in the kitchen. Correct and maintain by next routine inspection. Repeat
55 C 6-501.12: (A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
Observed the floor in the walk in cooler to be in need of cleaning. Clean and maintain by next routine inspection. Repeat
56 C 6-403.11: (A) Areas designated for EMPLOYEES to eat, drink, and use tobacco shall be located so that FOOD, EQUIPMENT, LINENS, and SINGLE-SERVICE and SINGLE-USE ARTICLES are protected from contamination. (B) Lockers or other suitable facilities shall be located in a designated room or area where contamination of FOOD, EQUIPMENT, UTENSILS, LINENS, and SINGLE-SERVICE and SINGLEUSE ARTICLES can not occur.
Observed a personal bag stored by the pizza boxes and the black serving plate dishes on the shelf. Store separately away from food and food equipment areas. Moved. COS
Inspection Comments   FACILITY IS COVERED WITH CFPM LICENSES FOR THIS INSPECTION.

THE LICENSES THOUGH, DO EXPIRE IN THE FALL (SEPT AND OCTOBER). PLEASE RENEW BEFOREHAND.
HACCP Topic: PROPER FOOD PREP HANDLING WHEN USING GLOVES
 

Person In Charge

  ANTONIO 		 

Date:

  05/04/2023
 

Inspector

  Angela Colon 		 

Follow-up:  Yes   No   Follow-up Date: